Green Manalishi SSTC (control unit) Sparky Projects 2018-08-28 | Part 1 of 2 videosI've been working on this for a while, the reason is that i am using a different approach that i haven't seen before, much of the circuit was experimental, everything looks promising, but haven't done a full run on it yetYou can find the basic diagram on my website, the modules are mostly off-the-shelf items from Amazon, basically a square wave oscillator, 2 amplifiers, the interrupter was from The Geek group (Now the National Science Institute) but not available atm.http://sparky-projects.co.uk/manalishi.html
Matrix Sequencer main panel Sparky Projects 2023-09-21 | Part of a large project, this is the heart of the system, the matrix boardSomething that @LOOKMUMNOCOMPUTER might be interested inLink to download page https://sparkys.tech/index.php?page=matrix_sequencerTech site: https://sparkys.techWebsite: http://sparky-projects.co.ukForum: http://sparky-projects.proboards.comDiscord: discord.gg/yPHpW2j
PCB overview Sparky Projects 2023-06-04 | Covering 3 pcb's which are somewhat related, as mentioned in the video i am still working on my new tech site, still keeping the original.You'll find the tech site in the links below, and from there you can follow to the projectsThe 'decatron' timer video with 6 modules youtube.com/watch?v=66FVVqb6LI8Website: http://sparky-projects.co.ukTech Site: https://sparkys.techForum: http://sparky-projects.proboards.comDiscord: discord.gg/yPHpW2j
Battery Packs, going bigger Sparky Projects 2022-11-08 | Next battery pack in line is the 27000mAh mini UPS, again from talentcell.com The previous packs were YB1203000 USB (3000mAh) and YB1208300 (8300mAh)I didn't go into detail on the chips, but check out the previous battery pack video hereyoutube.com/watch?v=9uxCw6ccc34The one thing i admire most in a company is their support, i wanted to change a connector in this pack, contacted the company, they responded within 15 minutes and sent out a few connectors.Website: http://sparky-projects.co.ukForum: http://sparky-projects.proboards.comDiscord: discord.gg/yPHpW2j
I didnt want to make this video .... Yet! Sparky Projects 2022-07-25 | Website: http://sparky-projects.co.ukForum: http://sparky-projects.proboards.comDiscord: discord.gg/yPHpW2j
Battery Packs Sparky Projects 2022-05-31 | Found some nice battery packs on Amazon recently, made by Talentcell, they have solid construction a syou'll see in the videoHere's the link to the 8300mAh pack, this should give you a start to find other sizessmile.amazon.co.uk/gp/product/B06Y5G3C8ZTo make these packs more useful. i am adding belt clips, if you decide to do the same, be careful when fixing them to avoid contact with batteries or circuit boardsWebsite: http://sparky-projects.co.ukForum: http://sparky-projects.proboards.comDiscord: discord.gg/yPHpW2j
Ioniser/ozone generator (read description) Sparky Projects 2022-02-15 | Described as"Ozonizer Ceramic Plate, Ozonizer Air Purifier,Portable 7g/h 110V/220V Ozone Generator with Double Sheet Ceramic Plate Air Sterilize "@bigclivedotcom has reviewed similar items with ceramic plates, but this has a double plate.I ddn't dig any further, but it looks like it's an astable multivibrator using just the 2 transistors on the heaatsink.Website: http://sparky-projects.co.ukForum: http://sparky-projects.proboards.comDiscord: discord.gg/yPHpW2j
Evolution of a PSU Sparky Projects 2021-12-18 | Website: http://sparky-projects.co.ukForum: http://sparky-projects.proboards.comDiscord: discord.gg/yPHpW2jThis started of as a project to add modern power supplies to an old power supply, but things took a turnThe new power supply unts are listed as 'Rui Deng' in searches, the ones i have are DPS5005 USB50V input max, 5 amp with USBTransformers are 2x24v 160VA which is 6.6 amps full load with windings paralleled, bridge rectifiers are 10A.Apologies for the quick ending, i knew my mic battery was low, but it turned out to be my second camera which should have been a close up of the units while i was showing the interface software (PIP), unfortunately that's lost.
Tape Deck Motor Speed Sparky Projects 2021-10-02 | Just a video to answer @Techmoan s question about speed control with capacitorsTechmoan's Video: youtube.com/watch?v=tkkx2h-rIEIYou'll find the capacitor at 18:57Bonusnuges channel youtube.com/user/bonusnudgesHe mostly had Diesel engines, but a few tape recorders tooWebsite: http://sparky-projects.co.ukForum: http://sparky-projects.proboards.comDiscord: discord.gg/yPHpW2j
Reversing Shaded Pole and Leslie Speakers Sparky Projects 2021-07-31 | Simple way to reverse shaded pole motorsLook Mum No Computer: youtube.com/channel/UCafxR2HWJRmMfSdyZXvZMTwMuseum Of Everything Rlse: youtube.com/user/sammybartlWebsite: http://sparky-projects.co.ukForum: http://sparky-projects.proboards.comDiscord: discord.gg/yPHpW2j
Making use of lenses Sparky Projects 2021-06-22 | Useful idea if you have spare camera lenses, although i didn't show it, i did a quick test with the film camera lenses and it seemed to work as well.I'm also thinking this may work on a telescope, would be good if anyone with a telescope could test and let me knowWebsite: http://sparky-projects.co.ukForum: http://sparky-projects.proboards.comDiscord: discord.gg/yPHpW2j
Use What You Have Sparky Projects 2020-08-12 | I had to drill 95 holes for my storage solutions video, and had some problemsI liked the storage tubes so much i wanted to drill a further 34 holes for diodes and transistors in another drawer, so this time i'll show you how i did it.Website: http://sparky-projects.co.ukForum: http://sparky-projects.proboards.comDiscord: discord.gg/yPHpW2j
Storage solutions (Computer Desk) Sparky Projects 2020-07-29 | Tubes: smile.amazon.co.uk/gp/product/B01N3BG424Handles: smile.amazon.co.uk/gp/product/B01LWKUF5KWebsite: http://sparky-projects.co.ukForum: http://sparky-projects.proboards.comDiscord: discord.gg/yPHpW2j
This is not a Decatron (plus gerber file) Sparky Projects 2020-06-24 | This is currently an incomplete project, but the display works and looks good, all that's left it the oscillator and controlsBut i thought i would release this now so that anyone who wants a decatron style display can get their own made from the gerber file, this took a bit of time to lay out, but i saved you the trouble, it's a modular system that can be as many digits as you wantLink to nixe counter youtube.com/watch?v=qS2osRTR1W4Link to construction video and gerber file youtube.com/watch?v=DIx6vNrS3sQWebsite: http://sparky-projects.co.ukForum: http://sparky-projects.proboards.comDiscord: discord.gg/m7BxFH
Odepro Hex62 EDC torch Sparky Projects 2020-05-31 | Although this torch was supplied for free, the rep said he was fine for me to do an honest review and tests.Please make up your own mind if you think this is a good torch.I thought about exploring the led module, but i didn't want to wreck a nice torch, i'll leave that to bigClive, unless odepro want to send me the electronics module with the led, and i can do a follow up.Link to Odepro Amazon page: amazon.co.uk/dp/B07VRMTWYMLink to Cree: cree.com/led-components/products/xlamp-leds-discrete/xlamp-xm-l2And for those wondering about Dyson's T shirt comment :http://www.odepro.com/es/2018-09-21_52726.htmlWebsite: http://sparky-projects.co.ukForum: http://sparky-projects.proboards.comDiscord: discord.gg/m7BxFH
Police WigWag light bar for models. Sparky Projects 2020-04-14 | Just a bit of fun with 555 IC's.Logic tester video youtube.com/watch?v=K0t_pqAhABwWebsite: http://sparky-projects.co.ukForum: http://sparky-projects.proboards.comDiscord: discord.gg/m7BxFH
What Is Power Factor Sparky Projects 2020-01-31 | Apologies for audio, i was using the camera mic and didn't want to reshoot
Using Transformers as Ballasts Sparky Projects 2020-01-26 | People ask if you have to short circuit the secondary of a transformer when it is used as a ballast for things like Tesla coils, this video should answer this question
Using Braided Sleeve Sparky Projects 2019-12-09 | How to get your wires through a braided sleeve, i show 3 ways
DC suppliy to house Sparky Projects 2019-11-24 | What happens if the supply to your house is changed to DC, will everything still work ?
Cable Manaement on the Computer Desk Sparky Projects 2019-11-23 | Just covering my ideas for managing the cables behind the desk
Computer Desk Rebuild Sparky Projects 2019-11-03 | So it got to the point where i could not get monitors to fit the frame i built over 4 years ago after a couple of monitors refused to work after a repair.The answer was to rebuild, this was helped largely due to an energy company rebate which meant i could complete the bottom row with all new monitors.The monitor stands are from 1home via Amazonamazon.co.uk/Monitor-Arms-Stands-1home-Accessories/s?rh=n%3A296770011%2Cp_4%3A1homeThe monitors are AOC, i have 2 x 19" and 2 x 22"amazon.co.uk/s?k=AOC&ref=nb_sb_noss
Stepper Motors: does polarity matter ? Sparky Projects 2019-10-19 | A question came up about polarity of stepper motos, hopefully this is answered.I have done a stepper motor video before, but this one concentrates on polarity
Useful (mystery) Tool Sparky Projects 2019-10-05 | This is a tool i've had for several years, occasionally it becomes very handy, only thing is, i don't know the name of it, or where you can get them.If you know these details, i will add them to these comments and pin your post.
A trip into history Sparky Projects 2019-06-14 | After my RCD (or gfci) tripped out sseveral times, i replaced it as i thought it had got weakened, so it's a good opportunity to take a look inside the old one.It works out that the test resistor is calculated to give a MAVIMUM offset current of 42mA (240 v/5600 ohms), but it's sensitivity can be adjusted down close to the 30mA.http://sparky-projects.co.ukpatreon.com/sparkyprojects
GL75 follow up Sparky Projects 2019-06-01 | A follow up to explain how the GL75 is wired for power.http://sparky-projects.co.ukpatreon.com/sparkyprojects
Exploring Bridges (Wheatstone) Sparky Projects 2019-04-29 | http://sparky-projects.co.ukpatreon.com/sparkyprojectsThe last video showed a simple method of measuring low resistance, this is a bit more complex because the device needs to be calibrated if you decide to build your own,.However, Wheatstone bridges are available in the usual places.The circuit i used as an example was from this sitehttp://www.rfcafe.com/references/popular-electronics/inexpensive-wheatstone-bridge-popular-electronics-march-1972.htm
low resistance without a microhm meter Sparky Projects 2019-04-07 | http://sparky-projects.co.ukpatreon.com/sparkyprojectsIn the video i use 10mA, this can be any appropriate current, it's best to use multiples of 10 for easier calculation, and once you work out the relationship of readings, it's easy to just look at the voltmeter, move the decimal point, and get a direct reading.Keep the current low, you don't want to burn out the trim resistor or the resistor under test.I was using a 5V power supply, but it's not important (but should be stable), as long as the 'power' doesn't stress the resistors
Can I use a variac as a current limiter ?? Sparky Projects 2019-02-25 | A question that pops up from time to time, i thought it a good idea to cover this topic.Website: http://sparky-projects.co.ukPatreon: patreon.com/sparkyprojects
Breadboard case Sparky Projects 2019-02-05 | Just a quickieAn idea for adding a control panel and storage for a breadboardMy original box needed a lid to stop wires and components falling out, so i decided to make the lid functional.http://sparky-projects.co.ukpatreon.com/sparkyprojects
Turning a corner Sparky Projects 2019-01-13 | The 'Throat depth# of my drill press isn't big enough to allow me to turn a large disc, or a long rod, so hopefully this will be a solution to the rare times i need to do thisI don't have the room for a permanent lathe, the one i had was too cumbersome to lift into place, and i don't have the room for a permanent place for it.Router Jig youtube.com/watch?v=-IRNXHCBHOQhttp://sparky-projects.co.ukpatreon.com/sparkyprojects
Does your soldering station have a fuse ?? Sparky Projects 2019-01-02 | Well of course mine does :DNo magic smoke for me..Apologies for audio.http://sparky-projects.co.ukpatreon.com/sparkyprojects
Laser Trigger Sparky Projects 2018-12-21 | Following the "Getting Attention" video, i have put the optical switch in a separate box, and made it more sensitiveI have also changed the optical fibre in the coil from a 'toslink' 1mm plastic fibre, to a 2mm glass fibre, which works much better.Getting Attention Video: youtube.com/watch?v=_Gbslc3FPgs
Getting Attention Sparky Projects 2018-12-09 | If you want to get the attention of an audience, you need to do something that makes them take notice, an explosion, a burst of fire, or in this case firing up a sparg gap Tesla coil, it's loud, and has a spark (albeit a small one)After a few iterations, i have finally constructed a compact Tesla coil there have been a few problems, the first design suffered from arcing, the second (in the box with a horizontal coil) also suffered from arcing from the secondary to the case, so the coil is now vertical.The other aspect i wanted was to be able to point the grounding rod (jesus stick or chicken stick) at the breakout point and have the coil fire up with the use of a laser pointer in the end of the stick.The idea is that the coil is disguised or hidden, only revealing what it is when fired up.This coil will have an unusual topload that no one will suspect, and it will seem as if the arcs are coming from the stick.I'm still having issues with the trigger circuit, but felt i needed to upload progress as it''s been a while since the last video.
YYYEEESSSSSS!! it works :D Sparky Projects 2018-11-18 | Well, a bit of a delay in getting this video out, had a few problems, but i got there in the endThis is just an indoor run, needs more tuning, but that can wait.This coil uses my synchronous (double contact) rotary spark gap, and my 'powerwall' transformer and capacitor set up.http://sparky-projects.co.uk
Garden run FAIL!!! Sparky Projects 2018-11-10 | We did a run of Green Meanie, my rotary gap (SRSG) Tesla coil, but then we got flashover from the rotary gap and that caused an issue.In this video i set about fixing the control consoleThe camera boom you can see in the video can be seen hereyoutube.com/watch?v=ELOT-RM7GmYWebsite with link to googlesite where the console diagram can be foundhttp://sparky-projects.co.ukThanks to Steve and Bruce for helping with the runyoutube.com/user/StevieLaneryoutube.com/user/bonusnudges
Can You Feel the Force ? Sparky Projects 2018-11-02 | Based on the circuit hereyoutube.com/watch?v=JBycGTmxlg4Music: Enter the Maze by Kevin MacLeod is licensed under a Creative Commons Attribution licence (creativecommons.org/licenses/by/4.0)Source: http://incompetech.com/music/royalty-free/index.html?isrc=USUAN1100782Artist: http://incompetech.com
Wood Fence Sparky Projects 2018-10-25 | I know the normal way to do this is to use a mitre fence, mine would be useless because you'll notice i start the cut with the board over the front edge, and i don't have a sled, i rarely do this sort of cut, so no need to make one.
Whats In The Box ??? Sparky Projects 2018-10-19 | I'm sure most of you can guess :Dhttp://sparky-projects.co.ukSparky and his Dad vid youtube.com/watch?v=zyUVUgSDRMs
Metrix Meter repair Sparky Projects 2018-10-12 | Steve and Bruce visited me last weekend, Bruce brought me this meter, but it had an intermittent fault, so this is the repair.
Turn it on or power up ? Sparky Projects 2018-10-08 | A little idea to make your control panels a little more interestingThis idea can be used for many things, possibly even props for cosplay etcti.com/lit/ds/symlink/lm3914.pdf
Dropback the Backdrop Sparky Projects 2018-09-28 | I needed to make the space i have more usable, but still wanted to divide the workshop and studio, so here's the solution.The original screen was a fixed frame.
Green Manalishi part 4 The PCB Sparky Projects 2018-09-23 | http://sparky-projects.co.uk/manalishi.htmlNot sponsored by JLCPCB or EasyEDAI've been playing with the above software wondering what Green Manalishi would look like on a PCB, EasyEDA takes a little getting used to, but i got there in the end, even setting the holes for stack mounting the main PCB and supply PCB.Hopefully i will be getting these made soon, not sure if i will be selling them, i would need good support from viewers.jlcpcb.comeasyeda.com
Green Manalishi (The circuits) SSTC without GDT ? Sparky Projects 2018-09-15 | Yep, i have got rid of the gate drive transformer.http://sparky-projects.co.uk/manalishi.htmlhttp://sparky-projects.co.uk/manalishicircuits.htmlOne thing i didn't mention was the BNC connector on the base, this is connected to the oscillator output and is intended for connection of a frequency meter and scope, the latter is for setting the mark/space ratio at 1:1
Green Manalishi SSTC (The Base) Sparky Projects 2018-09-03 | http://sparky-projects.co.uk/manalishi.htmlInitial testing was on low voltage with a 1Hz external oscillator, and LED's connected across each mosfet, this is the result youtube.com/watch?v=07pkkwPdU1oIn the last video i described the control unityoutube.com/watch?v=VNbHClgfpDIThis is the base unit that houses the driver electronics
Why are tripods like this, plus a camera tip. Sparky Projects 2018-08-19 | It seems that most tripods have this problem (except for ball head), though i do have one that's the correct way.For the adaptor i use, do a search for "Quick Release Adapter for Manfrotto Tripod 200PL-14 QR ", there are many sellers on Amazon etc.
Putting up some resistance Sparky Projects 2018-08-14 | I hope you watched this to the end ;)Just a quick excuse to show off a few variable resistors, and an insight into one of the things i used to do at school.
Is this meter working ? Sparky Projects 2018-07-28 | The normal way to check a meter is to use a multimeter to check the resistance, but doing that on this meter seemed to show open circuit, so you would think because of the 6KV full scale, that maybe there's over 20M Ohm of resistors inside, but that's not the case, see whyThis meter doesn't need a rectifier to work on ACMeter specs:Ernest Turner Electrostatic meterModel 32
Can a building be Square, Plumb AND Level ? Sparky Projects 2018-07-23 | This video didn't run as planned, but i ran out of wallpaper to do it again :PBut i think you get the idea.http://sparky-projects.co.uksites.google.com/site/sparkyprojects/other-info/building-anomolie
